導航：安全管理網>> 安全論文>> 化工安全論文>>正文

高石梯-磨溪區塊高壓氣井尾管固井技術

文檔作者：宋有勝鄒建龍趙寶輝劉愛萍文檔來源：中國石油集團海洋工程有限公司渤星公司中國石油集團鉆井工程重點實驗室固井技術研究室??油氣鉆井技術國家工程實驗室固井技術研究室		點 擊數：	更新時間： 2023年10月04日
下載地址：點擊這里	文件大?。?1.24 MB 共6頁	文檔格式： PDF	下載點數： 1 點（VIP免費）

全屏查看

內容預覽 [文件共6頁]

本文件共6頁，如需編輯使用，請下載。

注：預覽效果可能會出現部分文字亂碼（如口口口）、內容顯示不全等問題，下載是正常的。

	文件大?。?.24 MB 共6頁 文件格式：PDF 下載點數：1 點（VIP會員免費）

下一篇：高蠟原油開發中的防蠟清蠟技術進展

上一篇：關于油田地面集輸管網優化設計研究

文本預覽

僅提取頁面文字內容，供快速閱讀使用。

第34 卷 第2 期
2017 年3 月
Vol. 34 No. 2
Mar. 2017
鉆 井 液 與 完 井 液
DRILLING FLUID &amp;amp; COMPLETION FLUID
doi: 10.3969/j.issn.1001-5620.2017.02.020
高石梯- 磨溪區塊高壓氣井尾管固井技術
宋有勝，　鄒建龍，　趙寶輝，　劉愛萍
（中國石油集團海洋工程有限公司渤星公司??中國石油集團鉆井工程重點實驗室固井技術研究室??油氣鉆井技術國家工程實驗室
固井技術研究室，天津 300451）
宋有勝，鄒建龍，趙寶輝，等. 高石梯- 磨溪區塊高壓氣井尾管固井技術[J]. 鉆井液與完井液，2017，34（2）：111-116.
SONG Yousheng，ZOU Jianlong，ZHAO Baohui，et al.Cementing the φ177.8 mm Liner in the Block Gaoshiti-Moxi[J].
Drilling Fluid &amp;amp; Completion Fluid，2017，34（2）：112-116.
摘要　針對西南油氣田高石梯- 磨溪區塊高壓氣井φ177.8 mm 尾管固井遇到的氣層活躍、安全密度窗口窄、流體相容
性差及高溫大溫差等問題，制定了相應的固井技術措施。開發了適合高溫大溫差固井的自愈合防竄高密度水泥漿體系，并
進行了室內研究。結果表明：該體系密度為2.0～2.8 g/cm3，現場一次混配可達2.6 g/cm3 以上；適應溫度為常溫～180 ℃ ；
漿體的上下密度差不大于0.05 g/cm3 ；失水量不大于50 mL ；稠化時間與緩凝劑摻量具有良好的線性關系，稠化過渡時間不
大于10 min ；靜膠凝強度過渡時間不大于20 min ；24 h 抗壓強度大于10 MPa，水泥石頂部48 h 抗壓強度大于3.5 MPa，低
溫下強度發展快，形成的水泥石體積穩定不收縮，具有類似韌性水泥的力學性能；遇油氣產生體積膨脹，保證了界面膠結
質量和密封完整性，降低了固井后發生氣竄的風險。該固井技術在高石X 井和高石Y 井中進行了應用，固井優質率和合格
率得到較大幅度提高，水泥環后期不帶壓，獲得良好應用效果。
關鍵詞　天然氣井；固井；自愈合防竄高密度水泥漿；氣竄；漏失；大溫差；安岳氣田
中圖分類號：TE256.3　　　　文獻標識碼：A　　　　文章編號：1001-5620（2017）02-0111-06
Liner Cementing the high pressure gas wells in the Block Gaoshiti-Moxi
SONG Yousheng, ZOU Jianlong, ZHAO Baohui, LIU Aiping
(Boxing Subsediary of CNPC Offshore Engineering Company Limited??Research Center of Well Cementing Technology,
CNPC Key Laboratory of Drilling Engineering??Research Center of Well Cementing Technology, National Engineering
Laboratory of Oil &amp;amp; Gas Drilling Technology, Tianjin 300451)
Abstract In cementing the φ177.8 mm liner string in high pressure gas wells in the Block Gaoshiti-Moxi of southwest oilfield,
problems such as active gas zones, narrow drilling windows, poor compatibility of fluids and large temperature difference at high
temperatures, were encountered. Technical measures were prepared to deal with these problems, and a self-healing anti-channeling
high density cement slurry was developed for cementing wells with large temperature difference at high temperatures. Laboratory study
of the cement slurry showed that the cement slurry had density between 2.0 g/cm3 and 2.8 g/cm3, and in field application, the cement
slurry can be prepared to have a density of 2.6 g/cm3 in one mixing circulation. This cement slurry functioned at temperatures between
room temperature and 180 ℃. Differences between the density of the top and bottom of cement slurry column was less than or equal to
0.05 g/cm3. The fluid loss of the cement slurry was less than or equal to 50 mL. The thickening time had good linear relationship with
the concentration of retarders, and the transit time for the thickening of the cement slurry was not longer than 10 min. The maximum
transit time of the gel strengths of the cement slurry was 20 min. The 24-hour compressive strength of the set cement was greater than
10 MPa, and the 48-hour compressive strength of the cement top was greater than 3.5 MPa. The strength of the cement slurry developed
fast at low temperatures. The set cement formed had stable non-shrinking volume, possessing a mechanical performance that is similar
to that of tough cement. The cement slurry expanded when in contact with oil and gas, ensuring the quality of bonding between
基金項目：國家科技重大專項課題“深井超深井優質鉆井液與固井完井技術研究”（2016ZX05020-004）和中國石油天
然氣集團公司課題“復雜工況條件下固井密封力學機理及控制技術研究”（2016A-3904）。
第一作者簡介：宋有勝，高級工程師，1966 年生，畢業于天津大學應用化學系，現在從事固井技術研究和應用工作。
電話（ 022）66310307/13920263721;E-mail：songys@cnpc.com.cn。

網友評論 more

化工安全論文最新內容

03-11